Nowadays, we can often see the figure of Jinan color steel plate in the construction industry. It can provide people with residence and play a very important role in daily life. How much do you know about its anti-corrosion spraying techniques? Do you know what? Jinan color steel plate is introduced below, hoping to help you.

其防腐涂料可有效延长彩钢板的使用年限，而普通油漆只能起到临时表面掩盖的作用，很快将会出现爆皮及脱落现象，不能从根本上解决锈蚀问题，阻止生锈现象的发生。八大喷涂技巧如下所示：

The anti-corrosion coating can effectively extend the service life of color steel plate, while the ordinary paint can only play a temporary surface covering role, and the phenomenon of skin burst and falling off will appear soon, which can not fundamentally solve the corrosion problem and prevent the occurrence of rust phenomenon. The eight painting techniques are as follows:

济南彩钢板

Jinan color steel plate

1、按产品规定配比配制涂料，并搅拌均匀，熟化时间控制在30分钟，在6小时内施工完毕，涂装间隔短不能小于24小时，长不大于7天。

1. The coating shall be prepared according to the specified proportion of the product, and evenly stirred. The curing time shall be controlled within 30 minutes. The construction shall be completed within 6 hours. The coating interval shall not be less than 24 hours and the length shall not be more than 7 days.

2、施工所用工具应清洁干燥，涂料不得混有水分、香蕉水、醇类溶剂、汽油等及其它杂质，涂料现配现用，须在6小时内喷涂完毕，以防止结胶，造成不必要的损失，提高施工成本。

2. The tools used in the construction shall be clean and dry, and the coating shall not be mixed with moisture, banana water, alcohol solvent, gasoline and other impurities. The coating shall be sprayed within 6 hours when it is ready for use, so as to prevent glue formation, cause unnecessary loss and increase construction cost.

3、彩钢板厂家建议先采用水枪冲洗彩钢板，然后角向磨光机、钢丝刷、铁砂布等工具将基面灰尘、污垢、毛刺、水渍、油脂和老化的漆层等附着物清洗干净。

3. The manufacturer of color steel plate suggests that the color steel plate should be washed with water gun first, and then the dust, dirt, burr, water stain, grease and aged paint layer on the base surface shall be cleaned by angular polishing machine, wire brush, iron sand cloth and other tools.

4、喷涂施工前用毛刷或压缩空气格表面、阴角、沟槽的粉尘干净。

4. Before spraying, the dust on the surface, inner corner and groove of the grid shall be cleaned with brush or compressed air.

5、基面清理后经合格后可进行喷涂层施工。

5. The spraying layer can be applied after the base surface is cleaned and qualified.

6、确认无漏除、无锈粉的情况下进行涂层施工。

6. Coating construction shall be carried out without leakage and rust powder.

7、为防止二次污染，在基面处理后立即喷涂一遍。

7. In order to prevent secondary pollution, spray once immediately after base surface treatment.

8、施工温度在5度-35度，相对湿度百分之85，在有雨、雾、雪和较大灰尘条件下不可施工。

8. The construction temperature is between 5 ℃ and 35 ℃, and the relative humidity is 85%. The construction can not be carried out under the conditions of rain, fog, snow and large dust.

延长彩钢板使用寿命的做法

Practice of prolonging service life of color steel plate

1、一般彩钢板在风吹雨打几年之后就会呈现锈斑、腐蚀。假如想让彩钢板延伸寿数怎么做呢?能够每平米涂料用量不低于1公斤。在不明显进步施工本钱的情况下，可少延伸彩钢板使用寿数5~8年这样延伸寿数，下降施工本钱。

1. Generally, the color steel plate will show rust spots and corrosion after several years of wind and rain. If you want to let color steel plate extend life how to do? Can each square meter coating dosage not less than 1 kg. If the construction cost is not significantly improved, the service life of color steel plate can be extended for at least 5-8 years, which will reduce the construction cost.

2、要是彩钢板外表已经有生锈腐蚀的痕迹时就要打磨机或许砂纸将外表的浮锈打磨洁净，这些方法都能够将彩钢板防水的功能进步，让彩钢板不在被腐蚀，决裂。彩钢板为什么会漏水呢?有以下几种或许，彩钢板的斜度小，保温层的露出，装置时不作相应的处理，导致雨水直流进保温夹层，形成了所有为的雨水倒流。

2. If there are signs of rust and corrosion on the surface of the color steel plate, a grinding machine or sandpaper should be used to polish the surface rust. These methods can improve the waterproof function of the color steel plate, so that the color steel plate will not be corroded and cracked. Why does the color steel plate leak? There are several possibilities. The slope of the color steel plate is small, the insulation layer is exposed, and the corresponding treatment is not made during the installation, which leads to the direct flow of rainwater into the insulation interlayer, forming all the rainwater backflow.

3、彩钢板接缝很会导致彩钢板漏水，接缝时，看上去很好，但一条长长的缝隙经不起一小时的雨水冲刷，渗漏将浑水摸鱼。彩钢板装置时的钉子眼，也是漏水的直接原因，所以不只要产品质量好，并且装置的技能也要到位。

3. The seam of color steel plate will lead to water leakage of color steel plate. When the joint is made, it looks very good, but a long gap can't withstand an hour of rain washing, and the leakage will fish in troubled waters. The nail hole in the installation of color steel plate is also the direct cause of water leakage, so not only the product quality is good, but also the installation skills should be in place.

济南彩钢板

Jinan color steel plate

以上就是彩钢板厂家为大家介绍的关于济南彩钢板的八个防腐喷涂技巧以及保养的全部内容，相信大家看后也会有所了解，希望上述内容能对大家有所帮助，想了解更多详情，可以关注网站或者电话联系我们，随时欢迎大家前来参观选购。

The above is all about the eight anti-corrosion spraying techniques and maintenance of Jinan color steel plate introduced by the manufacturer of color steel plate. I believe you will understand after reading. I hope the above content can help you. If you want to know more details, you can pay attention to the website or contact us by phone. You are welcome to visit and purchase at any time.