您好,欢迎访问禹城泰瑞彩钢复合板加工厂!

服务热线

18765446878

热门关键词:禹城彩钢厂,禹城彩钢复合板,禹城钢结构板房 彩钢板房
当前位置:首页>新闻资讯>新闻动态济南彩钢板如何处理生锈的彩色钢板?

济南彩钢板如何处理生锈的彩色钢板?

来源:http://www.lxcaigang.com 日期:2020-08-04 发布人:
近年来,济南彩钢板在我们生活中的利用率越来越高。他的使用能显示出良好的生产力。彩钢板具有良好的保温效果,但也不是没有缺陷。长时间容易生锈,导致涂层剥落,影响正常使用。接下来,我想介绍一下如何处理生锈的彩色钢板。
In recent years, Jinan color steel plate in our life more and more high utilization. His use can show good productivity. Color steel plate has good heat preservation effect, but it is not without defects. It is easy to rust for a long time, resulting in coating peeling off and affecting normal use. Next, I would like to introduce how to deal with rusty colored steel plate.
1、彩钢板细部节点处理:
1. Treatment of detail joints of color steel plate:
(1)将彩钢板的固定部位重新铆接在屋脊罩上,彩钢板在屋脊罩上凸出,彩钢板与照明带的连接处出现缝隙。
(1) The fixed part of the color steel plate is riveted on the roof ridge cover again. The color steel plate protrudes on the roof ridge cover, and there is a gap between the color steel plate and the lighting belt.
(2)紧固件应紧固在屋顶系统紧固件不在的地方。
(2) Fasteners should be fastened where the roof system fasteners are not available.
(3)修整屋顶板的滴水处、压条和封边,确保所有钢构件和配件紧密贴合。
(3) Trim dripping, taping and edging of roof slab to ensure that all steel members and fittings fit closely.
(4)对于一些细节部分,应在详细处理时分别进行拆除和整改。
(4) For some details, they should be removed and rectified respectively during detailed treatment.
2、基层清理及处理:
2. Base cleaning and treatment:
(1)、拆除工作完成后,应对防水基层进行处理。
(1) After the demolition, the waterproof base should be treated.
(2)、彩钢板接头部分和固定螺丝部分用刷子反复处理,直干净;
(2) The joint part of color steel plate and the fixing screw part are repeatedly treated with a brush until they are clean;

(3)、基层清理和处理工作根据防水施工进度要求分别完成,以免因不及时施工而造成二次污染,需要再次清理;
(3) The base cleaning and treatment work shall be completed according to the waterproof construction schedule, so as to avoid secondary pollution caused by delayed construction and need to be cleaned up again;
(4)、将大量高的屋面密封胶,重新修补;
(4) Remove a large amount of high roof sealant and repair it again;
(5)、屋面施工前,需要先做密封胶施工,然后做附加层施工,然后整体施工。在上述工作修复之前,整体屋顶的照明带不得防水
(5) Before roof construction, sealant construction, additional layer construction and overall construction are required. The lighting strip of the whole roof shall not be waterproof until the above work is repaired
确保待安装的济南彩钢板的实际长度和相应彩钢板编号的长度应该非常清楚。板子的位置非常重要,应该放在正确的位置。檐口应加衬,后面板应平行于前面板并垂直于檩条。墙板无论檩条是否水平偏移,墙板应垂直排列,搭接处应协调一致,螺纹采用自攻钉,板与板之间的连接应增加自攻钉。
Ensure that the actual length of Jinan color steel plate to be installed and the length of corresponding color steel plate number should be very clear. The position of the board is very important and should be placed in the right position. Cornice shall be lined and back panel shall be parallel to front panel and perpendicular to purlin. No matter whether the purlin is horizontal offset or not, the wallboard should be arranged vertically, the lap joint should be consistent, the screw thread should be self tapping screw, and the connection between plate and plate should be added with self tapping screw.
保温棉铺设应保持连续性。每个人都不应该过度拧紧自攻螺钉,因为过度拧紧会降低垫片的密封性能。在严重的情况下,印板块的表面会下沉,水就会进入。彩板纵向搭接时,应按设计铺设密封条和密封胶,搭接时用自攻螺钉或垫片拉铆钉连接。应拉动密封条上的紧固件。
The laying of insulation cotton should be continuous. Everyone should not overtighten the self tapping screw, as over tightening will reduce the sealing performance of the gasket. In severe cases, the surface of the plate will sink and water will enter. When the color plate is longitudinally overlapped, the sealing strip and sealant shall be laid according to the design, and the self tapping screw or gasket rivet shall be used for connection. The fasteners on the weatherstrip should be pulled.
这是今天彩钢板制造商介绍的解决济南彩钢板锈蚀的相关内容。我相信当每个人都愿意这样做的时候,他们就会知道一些事情。如果有必要,他们可以稍后通过电话联系我们。
This is the related content introduced by the color steel plate manufacturer to solve the corrosion of Jinan color steel plate. I believe that when everyone is willing to do so, they will know something. If necessary, they can contact us by phone later.

联系电话:18765446878

咨询热线:18765446878(微信同号)

地址:禹城市十里望镇山东国际商贸港往南660米

备案号:鲁ICP备2023024436号 鲁公网安备37010202001695号 网站地图|XML|TXT

微信二维码

微信二维码